Items you'll need:
Malolactic culture - Liquid or Dry
Malolactic test kit
pH Test Kit
Free S02 Test Kit
What is Malolactic Fermentation?
Malolactic fermentation (MLF) describes a fermentation by bacteria (leuconostoc oenos) that are able to convert malic acid from grapes into lactic acid. It occurs alongside, and in addition to regular fermentation, and can be desirable for two reasons:
- Reducing excess acidity: By converting the relatively harsh tasting malic acid into the softer lactic, MLF softens the flavor of the wine.
- Adding complexity: In addition to converting the acid, malolactic bacteria can add a component of 'buttery' flavor (diacetyl), along with more complex flavors and aromas.
Uncontrolled MLF is very undesirable. In fact, the same bacteria responsible for reducing acidity are responsible for the production of sauerkraut, whose flavors and aromas are not what you would expect in a fine wine. In addition, if malolactic bacteria work in the presence of potassium sorbate (a preservative in kit wines and some commercial wines) it will produce geraniol, a compound that smells like a cross between ripe salmon and rotting geraniums.
Which wines should undergo malolactic fermentation?
Generally, wines made from grapes get malolactic treatment. Other fruit wines should not undergo MLF. There are two reasons for this, the first being that the bacteria needs a small amount of grape pulp and solids to get a foothold in the wine. Second, it is only really the top quality wines that merit malolactic treatment, and these are most often sold in the form of grapes.
Wines made from concentrate are generally unsuitable for malolactic treatment. Acidity is balanced toward the low side for early drinking, and the levels of solids in concentrate are virtually undetectable. Both of these traits are required for a proper MLF. In addition, some concentrates may have small amounts of sorbate in them, causing geraniol problems.
The MLF treatment criteria for wines are as follows:
- The wine should be one where complexity is desired over fruitiness. MLF tends to emphasize fermentation aromas and flavors and reduce the fresh fruity flavors of a wine. If this doesn't suit your palate, you should reconsider treatment.
- The wine must have an alcohol level below 14%. Malolactic bacteria are not especially alcohol tolerant, and a wine with a higher alcohol content will not support it.
- The wine must have a pH of 3.3 or greater. If you don't know what the pH is, get a pH test kit before attempting malolactic inoculation.
- The wine must have some grape pulp or yeast sediment to promote the growth of the bacteria. If it is clear, MLF will be very difficult to start.
What form does the malolactic bacteria come in?
There are two main types of malolactic culture available, refrigerated liquid culture, and freeze dried powder. They are both perfectly good choices for inoculating your grapes, and have to be kept refrigerated at all times.
What are some of the considerations when using malolactic fermentation?
In addition to transforming malic acid into lactic, leuconostoc oenos also transforms citric acid into acetic acid, which is the acid that gives vinegar it's distinctive flavor. This usually isn't a problem, unless the must has been treated with citric acid. Also, because it reduces fruity flavors, there are few white wines that will benefit from MLF, and some reds are best left fruity as well.
Because MLF can cause the pH of the wine to rise, it may make it more susceptible to other forms of bacterial infection. You may need to adjust sulfite levels to compensate.
Partial MLF, or ongoing malolactic fermentation can cause the wine to carbonate (become fizzy), break the bottle with CO2 pressure, push out the cork, and spoil the flavor. You must be certain that ML is complete and/or arrested before bottling. To ensure ML is complete, review the section below.
How do I go about starting malolactic fermentation?
Assuming you have purchased good quality grapes, you have tested the acid and pH, the first step is to obtain a malolactic bacterial culture. If you are only inoculating 6 gallons, (23 liters) of wine, you don't have to make a starter culture with either the freeze dried or liquid cultures. With the liquid culture package, when the grapes are almost finished the primary yeast fermentation, remove the ML culture from the refridgerator and allow it to come to room temperature near the wine. Your temperature should be 68-77° Farenheit (20-25°Celsius). Next, add the malolactic culture. Within two to three weeks the MLF will be well under way, and should be complete within two months.
With the freeze-dried culture it is necessary to make a sterile suspension and rehydrate the bacteria. For two grams of culture, prepare 25 ml of distilled water at 77-86° Farenheit (25-30° Celsius) in a sanitized cup and sprinkle the culture on top. After 15 minutes, stir with a sanitized spoon and add to your fermenting must. Again it is important that the must be below 5° Brix, so as not to slow the MLF.
Creating a starter culture for your wine (good for batches above 6 gallons)
If you are inoculating more than 6 gallons, you should purchase the culture about two weeks before your wine is nearly fermented dry, to allow time to make a starter culture. Judging the point when your wine will be two weeks away from dryness may seem difficult on first blush, but a good rule of thumb would be to purchase the culture the week before you receive your grapes.
Culture from liquid malolactic culture: Obtain 2½ liters of fresh grape juice. Choose a grape juice with less than 15 PPM of SO2, and with less than 20° Brix of sugar content. If you can't find an available juice with these characteristics, it is possible to change the pH and sugar content of a less suitable juice by either diluting with water or adding a pH adjuster. Ask your retailer for advice. Make sure you use only grape juice: apple juice or grape concentrate is not suitable.
Add about 1 gram of yeast energizer to the juice. This will help speed cell growth. Ensure the juice is between 77-86° Farenheit (20-25 °C) and inoculate with a package of malolactic friendly yeast (Epernay is ideal) and allow to sit for 2 days, and inoculate with liquid malolactic culture and maintain a temperature of 20-25°C.
After 12 days the culture will be ready. 2½ liters is sufficient for 30 gallons (120 liters) of wine. If you have more than 30 gallons, you can culture up the amount you need by simply adding your starter culture to larger amounts of suitable juice. You will need approximately ½ liter for every 23 liters of wine.
When is malolactic fermentation finished?
If the wine is kept at relatively warm temperatures (above 20°C) the fermentation will be complete within two months. Monitor MLF progress using a malolactic test kit. Once you are satisfied that your MLF is finished, you can stabilize your wine by adding sulfites to the level of approximately 50 PPM; test using a free S02 test kit. This will prevent the re-growth of any leuconostoc bacteria, and will prevent oxidation. It is a good idea to test the pH and acidity of your wine at this point as well using the pH test kit. MLF can cause the pH to rise, so it may need to be adjusted.
Making Wine from Grapes
Get to know the basics of making wine from grapes.
There's nothing more enlightening than to see the process first hand. Our video covers the different phases involved in the process of winemaking from grapes. (Crushing, pressing, fermenting, bottling) Not only will you discover the sheer enjoyment of winemaking, but you'll also reap the rewards of your efforts - every time you open a bottle.
Wine Making - Beer & Wine Hobby
Wine Making from Concentrates
Winexpert "I Made This" DVD
These easy-to-follow instructional videos for Winexpert kits will help you make the perfect wine every time! If you are just starting out, wine concentrates offer an easy way for you to get rolling. They come with simple directions and all the ingredients pre-measured and ready for use, that eliminates all of the guess-work. Concentrate kits produce impressive grape wines with remarkable flavor, body and character for a fraction of what they would cost you at the store. A truly rewarding hobby!